Bercomac 700458-1 Manual do Proprietário

1 BERCO Subframe with Electric Lift & Drive Mechanism for HUSQVARNA, ARIENS, POULAN, DIXON & WEEDEATER tractors *105599_EN* CAUTION: READ

8 NOTE: Use these same instructions for both sides of tractor. Manual Clutch: Install the new belt guides (item A) that are included with the drive m

9 ASSEMBLY Install the relay Install the support and winch control STEP 2: INSTALLATION OF THE CONTROL ASSEMBLY Install the relay (item 1). # Item De

10 ASSEMBLY CONNECTING THE WIRES NOTE:The posts on the relay are identified by numbers. (1-2-3-4). Install the wires from the winch on the posts of

11 ASSEMBLY CAUTION FOR YOUR SECURITY: Read and follow the safety precautions for the battery in the vehicle’s manual. CONNECT THE WIRES ON THE BATT

12 ASSEMBLY STEP 3: DRIVE MECHANISM INSTALLATION: WARNING TO PREVENT INJURIES: It is the person who installs the drive mechanism responsibility to m

13 ASSEMBLY For tractors with Electric Clutch: Install the belt on the engine pulley of the vehicle. Check the tension on the spring. If necessary,

14 IMPORTANT: Adjust the height of the three supports (items 1, 2 and 3) to make sure the drive mechanism pulley (item 4) is aligned with the engine p

15 OPERATION & MAINTENANCE CAUTION Read the vehicle Owner’s Manual carefully. Be thoroughly familiar with the controls & proper use of the a

16 TROUBLESHOOTING PROBLEM POSSIBLE CAUSES CORRECTIVE ACTION Winch runs backwards. Winch wires reversed. Recheck wiring. Switch wires reversed.

17 TORQUE SPECIFICATION TABLE GENERAL TORQUE SPECIFICATION TABLEUSE THE FOLLOWING TORQUES WHEN SPECIAL TORQUES ARE NOT GIVEN NOTE: These values a

2 LIMITED WARRANTY Bercomac Limitée 92, Fortin North, Adstock, Quebec, Canada, G0N 1S0 Conditions and Products Covered: BERCOMAC guarantees any par

18 PARTS BREAKDOWN COMPACT DRIVE MECHANISM 700458-1

19 Ref. Réf. English description Description française Qty. Qté. Part # Pièce # 1 Drive frame Châssis d'entraînement 1 104838 2 Drive frame

20 PARTS BREAKDOWN NORTHEAST DRIVE MECHANISM 700459-1

21 Ref. Réf. English description Description française Qty. Qté. Part # Pièce # 1 Drive frame Châssis d'entraînement 1 104838 2 Drive frame

22 PARTS BREAKDOWN SUBFRAME 700457-2

23 PARTS LIST SUBFRAME 700457-2 Ref. Réf. English description Description française Qty. Qté. Part # Pièce # 1 Female hitch Attache femelle 1 104

24 PARTS LIST SUBFRAME 700457-2 Ref. Réf. English description Description française Qty. Qté. Part # Pièce # 27 Relay Relais 1 105257 28 Instant

25 ATTACHMENTS ROTARY BROOM #700380 with nylon brush #700381 with polypropylene brush. Fits on same subframe as snowblower & utility blade. Requ

26 WHEN PERFORMANCE & DEPENDABILITY ARE NON NEGOTIABLE ! Ber comac Limit ée 92, Fortin North, Adstock, Quebec, Canada,

1 TABLE OF CONTENTS INTRODUCTION ...

2 INTRODUCTION TO THE PURCHASER This new accessory was carefully designed to give years of dependable service. This manual has been provided to ass

3 SAFETY PRECAUTIONS Careful operation is your best insurance against an accident. Read this section carefully before operating the vehicle and acces

4 OPERATION: 1. Do not put hands or feet near, under or inside rotating parts. 2. Exercise extreme caution when operating on or crossing gravel

5 SAFETY DECALS REPLACE IF DECALS ARE DAMAGED SEE PARTS BREAKDOWN FOR DECAL LOCATION DECAL #105133 To avoid serious injuries: Keep hands away from th

6 ASSEMBLY Install the supports (item 5) on each side of the vehicle. Item # Description Action 1 Carriage bolt, 3/8 x 1’’ (qty 6) Insert as shown

7 ASSEMBLY Install the female hitch between the two supports Install the female hitch (item 1) # Item Description Action 2 Hex bolt 3/8 x 1’’ (qt